一般情況下，無論是國產或進口，羅茨風機的使用壽命均在五到十年!之所以羅茨風機壽命跨度大，是受羅茨風機的使用環境、保養周期、使用壓力、供電系統等因素影響!因此，若想保證自己購買的羅茨鼓風機的使用壽命。需要注意以下幾點：

羅茨鼓風機的使用環境

羅茨鼓風機安裝時，盡量選擇空曠陰涼的位置進行安裝!避免安裝在環境封閉，空間狹小的地方。因為，空間狹小會影響羅茨風機的散熱，尤其是風冷式羅茨鼓風機，當然，若您購買的是水冷式鼓風機或沉水式鼓風機，那就無需考慮這個問題了。羅茨風機運行中產生大量熱量，容易出現松弛、皮帶打滑現象。

多臺羅茨鼓風機密集安裝或串聯安裝。

在一個房間安裝多個羅茨鼓風機時，如果羅茨鼓風機安裝密集，會出現散熱不良等問題，溫度升高會影響設備的使用。因此，建議仔細通風和散熱。同時，羅茨鼓風機不要串聯安裝!串聯安裝雖然可以增加壓力，但同時也會嚴重影響羅茨鼓風機的壽命!

設置在灰塵多的環境中。

如果安裝的羅茨鼓風機有大量的環境灰塵，羅茨鼓風機的過濾裝置會經常堵塞，過濾裝置堵塞后造成風量不足，電流過大，影響設備的正常使用。當風機過濾器中有大量灰塵時，葉輪也會出現磨損。從而影響羅茨鼓風機的壽命!

羅茨鼓風機的安裝和操作不當。

若羅茨鼓風機在安裝或操作中，存在一些違規操作，或安裝不當?shù)那闆r。也會影響羅茨鼓風機的壽命!特別是對于水產養殖、污水處理，在接收羅茨鼓風機試運行時，一定要按照出廠說明書的安裝操作流程進行，否則造成齒輪損壞，電機損壞，羅茨鼓風機停止工作的話，多數羅茨鼓風機廠家是不保修的。

平時不注意維護?！　×_茨鼓風機在日常使用中必須進行維護，例如易損件：皮帶的定期更換、潤滑油的更換、羅茨風機的清潔等。

以上便是羅茨鼓風機廠家總結的羅茨鼓風機使用壽命一般多少年，影響羅茨鼓風機使用壽命的五要素!

Generally, the service life of Roots blower, whether domestic or imported, is five to ten years! The reason for the long service life span of Roots blower is due to the operating environment, maintenance cycle, operating pressure, power supply system and other factors of Roots blower! Therefore, if you want to ensure the service life of your purchased roots blower. The following points should be noted:

Operating environment of Roots blower

When installing roots blower, try to choose an open and cool location for installation! Avoid installing in closed environment and narrow space. Because the small space will affect the heat dissipation of Roots blower, especially the air-cooled Roots blower. Of course, if you buy a water-cooled blower or submerged blower, you don't need to consider this problem. Roots blower generates a lot of heat during operation, which is prone to slack and belt slipping.

Multiple roots blowers are installed densely or in series.

When installing multiple roots blowers in a room, if the roots blowers are installed densely, problems such as poor heat dissipation will occur, and the temperature rise will affect the use of the equipment. Therefore, careful ventilation and heat dissipation are recommended. At the same time, roots blower should not be installed in series! Although the series installation can increase the pressure, it will also seriously affect the service life of Roots blower!

Set in dusty environment.

If the installed roots blower has a large amount of environmental dust, the filter device of Roots blower will often be blocked. After the filter device is blocked, the air volume is insufficient and the current is too large, affecting the normal use of the equipment. When there is a lot of dust in the fan filter, the impeller will also be worn. This will affect the service life of Roots blower!

Roots blower is improperly installed and operated.

If there are some illegal operations or improper installation during the installation or operation of Roots blower. It will also affect the service life of Roots blower! Especially for aquaculture and sewage treatment, when receiving roots blower for trial operation, it must be carried out according to the installation and operation process of the factory manual, otherwise the gear and motor will be damaged, and most roots blower manufacturers will not guarantee if roots blower stops working.

Don't pay attention to maintenance at ordinary times.

Roots blower must be maintained in daily use, such as vulnerable parts: regular replacement of belt, replacement of lubricating oil, cleaning of Roots blower, etc.

The above is the general service life of Roots blower summarized by Shanghai Ruizhe environmental protection, the manufacturer of Roots blower, and the five factors that affect the service life of Roots blower!